partially replacement of coarse aggregate by marble pieces

partially replacement of coarse aggregate by marble pieces

Recycled Plastics as Coarse Aggregate for Structural ...

aggregate in cement and concrete and found that crushed stone dust could be used to replace the natural sand in concrete. 2 Shukla et al. 1998 9 investigated the behavior of concrete made by partial or full replacement of sand by crushed stone dust as fine aggregate and reported that 40 percent sand can be replaced by crushed stone

Experimental Study on Partial Replacement of Cement with ...

A Preliminary Project Report on PARTIAL REPLACEMENT OF CEMENT WITH SUGARCANE BAGASSE ASH AND COARSE AGGREGATE WITH MARBLE WASTE Submitted in partial fulfillment of ...

Literature For Crushed Granite Stone As Replacement Of ...

coarse and fine aggregate. 2) Replacement of cement with glass powder in different water cement ratio. 3) In the present study the ordinary Portland cement was used. Further its mechanical properties can be compared by using different cement. 4) Study on replacing coarse aggregate with glass pieces …

literature for crushed granite stone as replacement of ...

Tests were conducted to determine the properties of plastic aggregate such as density, specific gravity and aggregate crushing value. As replacement of natural coarse aggregate (NCA) with plastic coarse aggregate (PCA) is not feasible, partial replacement at …

Partial Replacement of Fine Aggregate & Coarse Aggregate ...

These sand grains are between coarse aggregate (2mm to 64mm) and silt (0.004mm to 0.0625mm). Aggregate most of which passes 4.75mm IS sieve is used. 2.3 Coarse Aggregate Aggregates are the most mined material in the world. Aggregates are a component of composite materials such as concrete and asphalt concrete; the aggregate serves as

EXPERIMENTAL STUDY ON THE STRENGTH DEVELOPMENT …

of concrete cylinders and With Waste Marble Dust 4 concrete prisms of various replacements were used in total. The amounts of aggregate, water content, additives and cement are listed in the Table 1. Table 1. Mix Proportion S. No. Description Mass (kg/m3) 1 Cement 380 2 Fine Aggregate 710 3 Coarse Aggregate 1290 20 mm 645 10 mm 645

Glass Powder – A Partial Replacement for Cement?

These sand grains are between coarse aggregate (2mm to 64mm) and silt (0.004mm to 0.0625mm). Aggregate most of which passes 4.75mm IS sieve is used. 2.3 Coarse Aggregate Aggregates are the most mined material in the world. Aggregates are a component of composite materials such as concrete and asphalt concrete; the aggregate serves as

PARTIAL REPLACEMENT OF CEMENT AND FINE AGGREGATE WITH ...

Concrete is an advanced material in civil engineering. It is binding material made with cement, fine aggregate, course aggregate and admixtures in some cases. Nowadays developments of construction field, the worldwide consumption of natural materials is very high and at the same time production of solid waste from the destructions and production units are also very high.

PAPER OPEN ACCESS Related content Utilisation of Waste ...

for the replacement of fine aggregate in concrete. Aggarwal et al [3] observed that the bottom ash can be replaced as fine aggregate upto 50% without affecting the properties of concrete. Siva et al. [25] had done experimental investigation on partial replacement of fine aggregate using crushed spent fire …

Replacement of Coarse and Fine Aggregate by waste Ceramic ...

This paper aims to study experimentally, the effect of partial replacement of coarse aggregate by steel slag (SS), on the various strength and durability properties of concrete, by using the mix design of M40 grade. In this study, steel slag was used

Experimental study on strength characteristics on M25 ...

coarse and fine aggregate. 2) Replacement of cement with glass powder in different water cement ratio. 3) In the present study the ordinary Portland cement was used. Further its mechanical properties can be compared by using different cement. 4) Study on replacing coarse aggregate with glass pieces …

Suitability of Quarry Dust as a Partial Replacement of ...

Today construction cost is very high with using routine material like cement, fine aggregate and coarse aggregate. This study includes use of different waste material as a partial replacement of cement or fine aggregate or coarse aggregate. Industries in India produce lots of waste which may be useful in partial replacement of all the raw materials due to their different properties So hereby ...

The Utilization of Recycled Masonry Aggregate and Recycled ...

Recycled aggregates from CDW containing more than 50% of waste concrete, more than 20% of waste clay bricks, and around 20% of cement or mortar stone were also used as a partial replacement of natural aggregates for preparing concrete masonry blocks suitable for indoor applications [60,61]. In this research, full blocks of 95% RA and hollow ...

Glass Powder – A Partial Replacement for Cement?

INFLUENCE OF MARBLE DUST AS PARTIAL REPLACEMENT OF CEMENT IN CONCRETE The advancement of concrete technology can reduce the consumption of natural resources and energy sources and lessen the burden of pollutants on environment. Presently large amounts of marble dust are generated in natural stone processing plants with an important impact on ...

Effect of Partial Replacement of Cement by fly ash and ...

3.3 Coarse Aggregates Coarse aggregates are particles greater than 4.75mm, but generally range between 9.5mm to 37.5mm in diameter. They can either be from Primary, Secondary or Recycled sources. Primary, or '', aggregates are either Land- or Marine-Won. Gravel is a coarse marine-won aggregate; land-won coarse aggregates include gravel ...

Experimental Study on Partial Replacement of Cement with ...

rubber pieces are used a s partial replacement on aggregates i n t he mix. Ordinary Port land Cement, sand, and aggregate are used as the basic materials for concrete mix. 4 different mix which ...

(DOC) A Preliminary Project Report on PARTIAL REPLACEMENT ...

can be used as replacement to coarse aggregate as well as it can powder. In this research, the concrete having grade M60 is mix designed and the waste marble aggregates are partially replaced in high strength concrete by 0%, 10%, 20% and 30% of weight of natural coarse aggregate used. LITERATURE REVIEW There are numerous research reports ...

Analysis on Mix Design of High Strength Concrete (HSC ...

To overcome this problem, present study is focused on the suitability to utilize the quarry dust in Self Compacting Concrete (SCC) partially as fine aggregate with the natural fine aggregates. In this work, quarry dust is used as replacement of sand in a different level (0%, 15%, 30%, 45% and 60%) for producing the SCC.

Replacement of Coarse Aggregate by Using Naturally ...

Partial replacement of marble powder in cement accordingly in the range of 20%, 30%, 40%, by weight for M20 grade of concrete. ... Coarse aggregate: The 20mm size aggregates-The coarse aggregates with size of 20mm were tested and the specific gravity value of 2.78 and fineness modulus of 7 find and selected. The coarse aggregate fine angular ...

Waste Bakelite as Partial Replacement of Coarse Aggregate ...

25 concrete with partial replacement of cement with fly ash and coarse aggregate with coconut shell R. NAGALAKSHMI Abstract- An attempt has been made to examine the suitability of replacing the 20% of fly ash obtained from V.T.P.S; Vijayawada is common for all

A STUDY ON CONCRETE PROPERTIES USING STEEL SLAG AS PARTIAL …

aggregates and coarse aggregates without any replacement. The coarse aggregates was partially replaced by 5, 10, 15, 20 and 25% of bamboo. The fine aggregate was replaced by 15, 20 and 25% of Quarry dust with optimum replacement of 15% bamboo as coarse aggregate. The super plasticizer was used in all the mix apart from the control concrete.

Project on Partial Replacement of Cement with Marble Powder

The E- waste material is calculated on weight basis as coarse aggregate in the conventional mix: The fineness modulus of coarse aggregate with various E- waste contents is observed as 6.9. The divided particle size is assumed to be between 10mm and 20mm. Then E- waste particles can be considered as partial coarse aggregates.

Partial Replacement of Cement with GGBS in Concrete

Waste Bakelite as Partial Replacement of Coarse Aggregate in Building Blocks S.Sakthi Sasmitha1, Dr.R.N.Uma2 1Student M.E. (CEM), Civil Engineering Department, Sri Ramakrishna Institute of Technology/Anna University, Coimbatore, India. 2Head of Department, Civil Engineering Department, Sri Ramakrishna Institute of Technology/ Anna University,

Partial Replacement of E- Waste with Coarse Aggregate in ...

2.2. Tests on Coarse Aggregate (20mm Downsize Aggregate) The different tests conducted on coarse aggregate and the results obtained are as follows. The tests are conducted as per IS: 2386(part, 3)-1963(7). Sieve analysis The results of sieve analysis conducted on coarse aggregate are as shown in the Table 3.2.1. Sl. No IS Sieves (mm) Weight